Don't like the adverts?  Click here to remove them

Recent content by jimmyt

  1. J

    A/C Clutch not Engaging

    So just to close this one off. The offending part was the A/C CUT Water SW. These are about $150 from OEM and not much less for aftermarket ones, I have disconnected so the A/C works and will wait to get a second hand one.
  2. J

    Low Voltage - Dash illumination, Clock & Radio power

    Cheers. I would have hated to pay someone to find that....!
  3. J

    A/C Clutch not Engaging

    So I think this is the circuit for my HZJ80 which does not show a Relay for the Magnetic Clutch. It shows the A/C Water Switch charges the A/C CUT Relay (normally closed), I assume to CUt Out the A/C when the engine is running hot and thus help with engine cooling, however I cannot locate the...
  4. A-C Circuit.JPG

    A-C Circuit.JPG

  5. J

    A/C Clutch not Engaging

    Will do, just found another circuit diagram. It is possible my HZJ80 does not have a relay for Magnetic Clutch - just runs through A/?C CUT RELAY controlled by water temp sw. Will check for continuity here too. Possible corroded wire. Cheers. James
  6. J

    Low Voltage - Dash illumination, Clock & Radio power

    All For records folks; the corroded wire was in this location buried about 30mm from the bulkhead. See Blue & Yellow wire in image fixed with heat shrink now protecting. James
  7. CorrodedWire.JPG

    CorrodedWire.JPG

  8. J

    A/C Clutch not Engaging

    OK folks, I can see that this topic has been touched on before but the threads have not solved my issue. The scenario is thus: 1993 80 Series Land Cruiser: A/C Magnetic Clutch is not engaging when A/C button pressed. Cannot find Magnetic Clutch Relay. The Magnetic Coil has been replaced and...
  9. A-C Relay.JPG

    A-C Relay.JPG

  10. J

    Low Voltage - Dash illumination, Clock & Radio power

    I will do. Just back of holiday.
  11. J

    Low Voltage - Dash illumination, Clock & Radio power

    Found it...and fixed it ! Managed to isolate the area of concern and eventually found a heavily corroded wire inside loom engine bay just before bulkhead... Now to re wrap loom and reassemble the dash.... Hope there are no more....
  12. J

    Low Voltage - Dash illumination, Clock & Radio power

    Towpack, thanks for the response. I have not noticed any windscreen leaks however it has been submerged (previous owner) in water at some point so it sounds like I may need to get behind the dash to see if these has been any internal loom corrosion. May be good to get it all out anyway...
  13. J

    Low Voltage - Dash illumination, Clock & Radio power

    Hi All Vehicle 1993 80 Series; HZJ80 My dash illumination, clock and radio are not works so I set about looking for the issue. I am not the best on electrical issues but understand the basics, I think…! Can anyone help. Ignition voltage a healthy +12v Constant Battery Voltage is a dismal...
  14. 4.JPG

    4.JPG

  15. 3.JPG

    3.JPG

Back
Top